铁泥氧化制备颜料铁红的研究

以工业废渣铁泥为原料,经拌酸氧化制备铁红颜料,探讨了酸的种类、浓度及用量和氧化温度及时间对产品质量的影响。结果表明,较佳的工艺条件为:硫酸浓度60%,硫酸与铁泥质量比1∶1.2,氧化温度800℃,氧化时间2.0 h,得铁红产品,质量符合油漆、涂料等对铁红颜料的要求。     

中低品位膨润土的有机化及在泥浆中的应用

以新疆乌兰陵格产中低品位钠基膨润土为原料,用十六烷基三甲基铵盐(氯化物D1631和溴化物CTAB)作插层剂,制备有机膨润土。通过实验确定了制备有机膨润土的季铵盐加入量是85～90mmol/100g土。用红外(FTIR)、X-衍射(XRD)和扫描电镜(SEM)表征了有机土结构。FTIR谱显示有机插层剂已进入膨润土的层间,XRD特征峰位移表明膨润土的层间距由1.23nm增加到3.26nm。SEM观察到有机土形貌显著改变,颗粒松散。结果表明膨润土的层间距增大,粒层厚度约为72nm左右。测试了有机膨润土的钻井油基泥浆性能,结果表明,其塑性粘度为7.0mPa·s,表观粘度为8.5mPa·s,动切力为1.5Pa,滤失量40.0mL,均已达到钻井液用有机土的质量指标要求。     

子午线轮胎生产设备的国产化及其存在的问题

对生产子午胎的九大类主要设备：炼胶设备、帘布覆胶设备、覆胶帘布裁断设备、复合挤出机及其生产线、钢丝圈设备、内衬层（气密层）生产线、成型设备、硫化机、成品检测设备进行了分析，总结介绍了我国橡机企业在这九大类设备的设计制造方面取得的成绩和水平，并与国际现状进行了对比。最后总结了我国子午胎设备目前的优势和不足。     

厌氧污泥处理含铬废物的研究

利用城市污水处理厂的厌氧污泥对含铬废物进行解毒研究,结果表明,在厌氧条件下,厌氧污泥对重铬酸钾溶液和铬渣进行解毒后,滤液中的Cr6+质量浓度极低,大大低于《污水综合排放标准》的0.5 mg/L。厌氧污泥的解毒效果与含铬物料的量、解毒时间等因素有关。     

基于神经网络的轮胎胎号字符识别

介绍了采用BP神经网络来进行轮胎胎号字符识别的一种尝试性方法。用Matlab来模拟用神经网络进行胎号数字识别这一过程，用投影—变换系数法进行特征提取，确定特征输入、隐含层的神经元和输出后，经训练后可识别胎号，识别率尚可。     

滚动轮胎表面对流换热的萘升华模拟研究

根据热质比拟的基本原理 ,采用萘升华技术 ,在风洞中利用直线运动的旋转圆盘模拟研究了滚动轮胎表面的对流换热系数。当风速为 14m·s- 1 时 ,轮胎表面对流换热系数与汽车行驶速度呈线性关系 ,随着汽车行驶速度的增大 ,轮胎表面对流换热系数也增大 ,其经验式为h =5 2 99+1 2 43 8v。     

骨架材料对全钢载重子午线轮胎性能的影响

讨论骨架材料的规格、结构分布及工艺控制对全钢载重子午线轮胎性能的影响。胎体帘布采用带有外缠丝的 3 + 9+ 15× 0 2 2 + 0 15规格钢丝、胎体帘线密度在 45 0～ 65 0根·m- 1 范围内 (帘线直径大于 1 2mm)以及胎体反包端点在成品外轮廓曲线的第 2或 3条装配线上等措施均有利于保证胎体强度 ;合理设计带束层结构 ,端点与胎侧肩部花纹距离取 10mm左右有利于消除应力过度集中 ;采用钢丝增强带有利于提高胎圈刚性。     

尼龙斜交载重轮胎早期损坏原因及解决方法探讨

针对尼龙余交载重轮胎使用过程中出现的早期损坏，分析了其使用因素和设计因素，从配方设计、结构设计等方面提出了相应的解决方法。同时认为加强工艺控制与结构、配方设计对轮胎性能的影响同等重要。     

Bauxite residue (red mud) increases phosphorus retention in sandy soil catchments in Western Australia

The Peel-Harvey estuary on the Swan Coastal Plain, Western Australia has become eutrophic partly because of the leaching of fertiliser phosphorus from sandy soils. The acid, coarse textured sandy soils are predominantly quartz, have a low iron and aluminium content and do not retain phosphorus. Red mud, derived from bauxite, is a by-product of the alumina industry and has the ability to retain phosphorus. Retention of phosphorus is enhanced when the red mud is neutralised with gypsum. Red mud has been suggested as a soil amendment to reduce phosphorus leaching.To investigate the reduction in the leaching of phosphorus from soils amended with red mud, weirs were constructed at the outlets from a pair of catchments to quantify the amount of phosphorus in the streamflow. Both catchments were deep grey Bassendean sand. One of the catchments was treated with 80 t/ha of red mud which had been neutralised with waste gypsum from the phosphate industry. The red mud was applied to the soil surface using conventional fertiliser spreading equipment. The other catchment was untreated.The red mud reduced phosphorus loss by 70% from 13.8 kg/ha on the untreated catchment, to 4.2 kg/ha on the treated catchment. Both catchments were treated with 20.4 kg/ha of phosphorus as superphosphate. The catchment treated with red mud also received a further 41.5 kg/ha of phosphorus from the phosphogypsum that was used to neutralise the red mud.Our results show that red mud reduces phosphorus leaching and is potentially a nutrient management option in sandy soils. Red mud has the potential to reduce the impact of agriculture on the estuarine environment and has implications for the continued expansion and intensification of agriculture in the Peel-Harvey catchment.     

氧化铝生产赤泥附液吸收H_2S实验研究

对氧化铝生产附产赤泥吸收净化H2 S废气进行了实验研究 ,赤泥附液吸收H2 S具有吸收效率高、吸收容量大、易控制 ,操作简便等优点 ,在较少时间内对H2 S的吸收效率保持在 90 %以上。